Effects of EGR on performance and emissions of a diesel engine fuelled with balanites aegyptiaca/diesel blends

In this study, balanites Aegyptiaca (L.) Del biodiesel was blended in proportions of 10% and 20% on the volume basis with diesel fuel and tested in a single cylinder, VCR diesel engine under measured load conditions with varied EGR rates (0, 10 and 20%). The results showed that B10 and B20 blends shown a significant reduction rate in terms of NO_x emissions that were familiar with biodiesel blends. At peak load conditions, BTE increased slightly for test fuel blends compared with pure diesel fuel while the BSFC rate and EGT suffered from increasing and decreasing nature with respect to blending percentage. From the emissions point of view, with the increase in blends percentage, a significant reduction rate is observed in terms of CO and HC concentrations (up to 12.34 and 17.5%, respectively) while NOx emissions decreased at peak load conditions (up to 24.34%). HC and CO emissions decreased with increase in blends percentage. However, lower levels of NO_x and EGT (up to 21.37 and 8.47%, respectively) and the average increase in terms of BTE and BSFC (up to 2.83 and 2.9%, respectively) can be realised with B20 test fuel blend under 20% EGR rate.     

一株耐盐柴油降解菌的分离鉴定及其降解性能

从某油田附近受石油污染土壤中分离出一株以柴油为惟一碳源的耐盐菌株LS1。通过对菌株的生理生化特性、菌体的形态观察及16S r DNA基因序列分析鉴定菌株LS1为假单胞菌属(pseudomonas)。该菌株可耐受的最高盐度(Na Cl)和柴油浓度分别为6%~8%和12 000 mg/L。菌株生长的适宜p H和温度条件分别为6.0~8.0和28~36℃。在盐度为6%、p H为7.0、温度为32℃、菌种投加量为10%的条件下,初始浓度为3 000 mg/L的柴油经6 d降解后,去除率可达78.3%,加入适量外加碳源葡萄糖和蔗糖,可使降解率分别提高至92%和90%左右。菌株LS1的耐盐机理可能是通过在细胞内积累甜菜碱以调节菌株细胞内外渗透压平衡。投加甜菜碱可提高耐盐菌LS1在高盐环境下对柴油的降解效率。     

长大区间隧道抽出式串联通风机排烟能力实验研究*

为实现有效通风以降低隧道火灾带来的损失和伤亡,依托青岛市地铁8号线大洋站至青岛北站区间隧道,建立线性比尺为1∶15的隧道通风排烟模型实验系统,针对通风机串联单抽,围绕3种通风机频率匹配组合,测定单机的变频频率值、电功消耗、排烟道与行车道的断面平均风速以及右侧行车道静压。研究结果表明:在相同功率消耗下,不同频率匹配的串联通风机排烟效果存在差异;针对此差异,利用气体挡烟墙性能及其计算欧拉数值比较发现,风井近端的通风机频率较大时,下游对污染气流的抵抗力更强,拥有更好的排烟效果。研究结果可为隧道火灾提供更有效率的防灾救灾数据支持,并从欧拉数方面为研究隧道临界风速提供新角度。     

内蒙古自治区机动车尾气污染监控体系初探

随着机动车大量开始进入普通家庭,内蒙古自治区机动车保有量快速增长,使得机动车排气污染已经成为城市大气污染的重要来源。因此,开展在用机动 车排气污染防治工作,建立切实有效的机动车排气污染监控体系刻不容缓。本文对内蒙古自治区在用机动车排气污染监控体系和保障好保障体系建设内容进行了初探。     

低温柴油吸收工艺在高温油品储罐罐顶废气净化中的应用

采用罐区减排措施和低温馏分油吸收-脱硫工艺处理高温油品罐罐顶废气,在处理气量43.0~384.5 m3/h,柴油流量10~20 m3/h,吸收柴油温度10~15℃条件下,废气经过净化后,硫化氢和有机硫化物去除率大于97.2%,净化气体非甲烷总烃浓度小于8.35 g/m3,均低于GB20950-2007《储油库大气污染物排放标准》和GB 16297-1996《大气污染物综合排放标准》中相关污染物的限值。     

激光烧蚀皮革过程中的废气成分研究

皮革在激光烧蚀过程中会产生大量具有恶臭气味的有机废气,严重影响空气质量。为了评估该类型气体危害,分别利用紫外可见分光光度计和气相色谱-质谱联用仪,检测了天然皮革和人造革在激光烧蚀过程中的废气成分。结果显示烧蚀天然皮革所产生的废气中含有NO、NO2、SO2、二氨基丙烷和丙烯酸甲酯,烧蚀人造革所产生的废气中含有NO、NO2、甲硫醇、二硫化碳、乙二醇、二甲基二硫醚、丙二醇、乙二醇二甲醚和硫代乙酸甲酯。其中,甲硫醇、二硫化碳、二甲基二硫醚和乙二醇二甲醚都是产生恶臭的有机成分。研究为该类型废气的治理提供了基础数据和依据。     

机动车排气检验机构的环境影响评价研究

机动车排气定期检验机构对周边环境质量的影响虽然不大,但由于大多处在闹市区,贴近敏感人群,其噪声与机动车尾气对市民的影响却不容忽视。通过环境影响评价,分析机动车排气定期检验机构的环境影响特点,并结合机动车排气定期检验业务流程,对机动车排气定期检验机构的整体规划与布局提出合理建议,对噪声与大气污染物排放提出有效控制措施,不仅可以有效控制机动车排气定期检验机构对周边大气环境质量的影响,也能有效减小噪声对周边市民日常生活的影响。     

某大型钢结构项目喷涂废气污染防治措施可行性分析研究

钢结构建筑是一种新型的节能环保的建筑体系,大多数大型钢结构产品在生产过程中均需要进行抛丸除锈、喷涂处理,使用油漆进行喷涂过程中将不可避免地产生含TVOC(主要为甲苯、二甲苯和非甲烷总烃)的有机废气。大型钢构类生产项目喷涂废气的收集和处理尤为困难。文章结合某大型钢结构生产企业实际采取的喷涂废气治理方法进行喷涂废气污染防治可行性分析,旨在为同类项目喷涂废气污染治理及进一步改良涂装废气治理工艺和技术提供参考依据。     

Carbonyl emissions from heavy-duty diesel vehicle exhaust in China and the contribution to ozone formation potential

Fifteen heavy-duty diesel vehicles were tested on chassis dynamometer by using typical heavy duty driving cycle and fuel economy cycle. The air from the exhaust was sampled by 2,4- dinitrophenyhydrazine cartridge and 23 carbonyl compounds were analyzed by high performance liquid chromatography. The average emission factor of carbonyls was 97.2 mg/km, higher than that of light-duty diesel vehicles and gasoline-powered vehicles. Formaldehyde, acetaldehyde, acetone and propionaidehyde were the species with the highest emission factors. Main influencing factors for carbonyl emissions were vehicle type, average speed and regulated emission standard, and the impact of vehicle loading was not evident in this study. National emission of carbonyls from diesel vehicles exhaust was calculated for China, 2011, based on both vehicle miles traveled and fuel consumption. Carbonyl emission of diesel vehicle was estimated to be 45.8 Gg, and was comparable to gasolinepowered vehicles （58.4 Gg）. The emissions of formaldehyde, acetaldehyde and acetone were 12.6, 6.9, 3.8 Gg, respectively. The ozone formation potential of carbonyls from diesel vehicles exhaust was 537 mg O3/km, higher than 497 mg O3/km of none-methane hydrocarbons emitted from diesel vehicles.     

Experimental study on filtration and continuous regeneration of a particulate filter system for heavy-duty diesel engines

This study investigated the filtration and continuous regeneration of a particulate filter system on an engine test bench, consisting of a diesel oxidation catalyst（DOC） and a catalyzed diesel particulate filter（CDPF）. Both the DOC and the CDPF led to a high conversion of NO to NO2 for continuous regeneration. The filtration efficiency on solid particle number（SPN） was close to100%. The post-CDPF particles were mainly in accumulation mode. The downstream SPN was sensitively influenced by the variation of the soot loading. This phenomenon provides a method for determining the balance point temperature by measuring the trend of SPN concentration.